Product ID:IMRON PRIMERS & ENAMELS, 326Y67846
MSDS Date:01/01/1991
FSC:8010
NIIN:00N041009
MSDS Number: BSGWS

E I DU PONT DE NEMOURS & CO INC

1007 MARKET ST
WILMINGTON, DE 19898
US

Emergency Phone: 800-441-3837;800-424-9300(CHEMTREC)

Info Phone: 800-346-4748

Cage: B0589

E I DU PONT DE NEMOURS & CO

BRUSSEL, DE 19898 BE

Telephone: 32-(0)15-401.505

Cage: B0589

IRREG HEART BEATS IN ANIMALS & OCCASNL

RTECS: 9999999ZZ

SHOWN MILD INJURY TO OLFACTORY REGION OF NOSE. ING

RTECS: 9999999ZZ

SECONDARY ANEMIA & INCR IN WHITE BLOOD CELLS, FATTY

RTECS: 9999999ZZ

MAY CAUSE MOD EYE BURNING.

RTECS: 9999999ZZ

SEVERAL STUDIES EVALUATING PETROLEUM

RTECS: 9999999ZZ

OR AN INCR IN KIDNEY/LIVER TUMORS. MAY CAUSE

RTECS: 9999999ZZ

SHORTNESS OF BREATH.

RTECS: 9999999ZZ

AIR RESP (TC19C PREF, OTHERWISE TC23C).

RTECS: 9999999ZZ

(TERGITOL TMN-10 OR EQUIV), 80% WATER; OR 0-10%

RTECS: 9999999ZZ

WASTE CONTAINER FOR 48 HOURS TO ALLOW CARBON DIOXIDE

RTECS: 9999999ZZ

IN WELL-VENTD AREAS, A NEGATIVE-PRESS,

RTECS: 9999999ZZ

BEEN PROPERLY FIT TESTED FOR THE RESP. FOLLOW RESP

RTECS: 9999999ZZ

184 @ 20C

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 1%

OSHA PEL 750 PPM; 1000 STEL

ACGIH TLV: 750 PPM; 1000 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

71 @ 20C

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

36.7 @ 20C

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 2%

OSHA PEL 100 PPM; 150 STEL

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

0.2 @ 20C

76

CAS: 141-78-6

RTECS: AH5425000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENE

CAS: 108-65-6

RTECS: AI8925000

ACRYLIC POLYMER

CELLULOSE ACETATE BUTYRATE

CAS: 9004-96-8

OSHA PEL 15 MG/M3; 5 RESP

ACGIH TLV: 10 MG/M3

VM & P NAPHTHA

CAS: 64742-89-8

OSHA PEL 300 PPM; 400 STEL

ACGIH TLV: 300 PPM

MINERAL SPIRITS

CAS: 64742-88-7

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 10 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

IRON (III) OXIDE; (IRON OXIDE)

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3

ACGIH TLV: 5 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:NOTE:TOLUENE APPEARS ON NAVY LISTING
OF OCCUP CHEM REPROD HAZ. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLNG & EXPOS
RECOMMENDATIONS . INGEST:GI DISTRESS. INHAL:MAY CAUSE NOSE/THROAT
IRRIT. RPTD/PRLNGD OVEREXPOS TO SOLVS MAY LEAD TO PERM BRAIN (EFTS
OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:& NERV SYS DAM. EYE
WATERING/HDCH/NAUS/DIZZ/LOSS OF COORD ARE SIGNS THAT SOLV LEVELS
ARE TOO HIGH. SKIN/EYE CONT:MAY CAUSE IRRIT/BURNING OF EYES.
RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN IRRIT W/D ISCOMFORT/DERM. ING
2:HIGH CONC HAVE CAUSED EMBRYOTOX EFTS IN LAB ANIMALS. IT HAS BEEN
DEMONSTRATED TO (SUP DAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS W/HISTORY OF LUNG OR
BREATHING PROBLEMS OR PRIOR REACTION TO ISOCYANATES SHOULD NOT USE
OR BE EXPOSED TO THIS PRODUCT.

First Aid:INGEST:CALL MD IMMEDIATELY & HAVE NAMES OF INGREDIENTS
AVAILABLE. INHAL:IF AFFECTED BY INHALATION OF VAPOR/SPRAY MIST,
REMOVE TO FRESH AIR. IF BREATHING DIFFICULTY PERSISTS/OCCURS LATER,
CONSULT MD. E YES:IMMEDIATELY FLUSH W/PLENTY OF WATERFOR AT LEAST
15 MINS. CALL MD. SKIN:WASH W/SOAP & WATER. IF IRRITATION OCCURS,
CONTACT MD.

Flash Point Method:CC
Flash Point:73.0F,22.8C
Lower Limits:0.9%
Upper Limits:13.1%
Extinguishing Media:WATER SPRAY, FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER FROM FOG NOZZLES MAY BE USED TO COOL
CLOSED CONTAINERS TO PREVENT PRESSURE BUILD UP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE FLASH POINT, EMITS
FLAMM VAPORS WHICH, WHEN MIXED W/AIR, CAN BURN OR BE EXPLOS. FINE
MISTS/SPRAYS MAY BE FLAMM AT TEMPS BELOW FLASH POINT.

Spill Release Procedures:VENT AREA. REMOVE SOURCES OF IGNIT. PVNT SKIN
CONT/BRTHG OF VAP. WEAR NIOSH/MSHA APPRVD PROP FIT VAP/PARTICULATE
RESP (TC23C). CONFINE/REMOVE W/INERT ABSORB. IF MATL HAS BEEN
ACTIVATED W/ISOCYANATE, W EAR NIOSH/MSHA APPRVD POS PRESS SUPPLIED
(ING 20)
Neutralizing Agent:SEE SPILL/RELEASE PROCEDURES.

Handling and Storage Precautions:DO NOT STORE >120F. OBSERVE LBL PRECS.
KEEP AWAY FROM HEAT, SPARKS & FLAME. CLOSED CONTR AFTER EACH USE.
GROUND CONTRS WHEN POURING.
Other Precautions:DO NOT BREATHE VAPORS OR MISTS. DO NOT SAND, FLAME
CUT OR WELD DRY COATING W/OUT NIOSH/MSHA APPRVD RESPIRATOR OR
APPROPRIATE VENTILATION. DO NOT PERMIT ANYONE W/OUT PROTECTION IN
PAINTING AREA.

Respiratory Protection:ALL NIOSH/MSHA APPRVD:WEAR RESP AT ALL TIMES
WHEN HNDLNG ISOCYANATE ACTIVATED MATLS. WEAR POS PRESS,
SUPPLIED-AIR RESP (TC19C) DURING SPRAY APPLICATN OR BRUSH/ROLL
APPLICATN IN POORLY VENTD AREAS. FOR MIXING OR BRUSH/ROLL
APPLICATN (ING 23)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES RECOMMENDED.
Eye Protection:ANSI APRV CHEM WORK GOGG .
Other Protective Equipment:COVERALLS RECOMMENDED
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE EATING
OR SMOKING.
Supplemental Safety and Health
EFTS OF OVEREXP:POTENTIATE PERIPHERAL NEUROPATHY CAUSED BY EITHER
N-HEXANE OR METHYL N-BUTYL KETONE. MEK BY ITSELF HAS NOT BEEN
DEMONSTRATED TO CAUSE PERIPHERAL NEUROPATHY. LIQ SPLASHED IN EYE
MAY RSL T IN CHEM BURNS. ING 3:RECURRENT OVEREXPOS MAY RSLT IN
LIVER/KIDNEY INJURY. HIGH AIRBORNE LEVELS HAVE PRDCED (ING 13)

Boiling Pt:B.P. Text:>129F,>54C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.994-1.45
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:MISCIBLE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:50-71

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORESEEABLE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, SMOKE
& OXIDES OF HEAVY METALS REPORTED IN INGREDIENT SECTION.

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE
W/FEDERAL, STATE & LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.